Ask Experts Questions for FREE Help !
Ask
    topfuel's Avatar
    topfuel Posts: 1, Reputation: 1
    New Member
     
    #1

    Mar 2, 2011, 02:22 PM
    What happens if lp converter not installed on amana gas furnace?
    My amana gas furnace was not converted to propane when hvac guys instlled it and has been running on propane. I've used 600 gallons of fuel and have repeatedly complained about strong odors, black sutte exhaust vent, and high fuel costs. When the problem was discovered I was told just to do the conversion and everything would be OK.
    I question this.
    T-Top's Avatar
    T-Top Posts: 1,871, Reputation: 100
    Ultra Member
     
    #2

    Mar 2, 2011, 05:02 PM
    The system will need a good cleaning. You will have soot build up inside the heat exchanger, collector box,inducer wheel and housing. If not properly cleaned after conversion the restriction will get worse.
    mygirlsdad77's Avatar
    mygirlsdad77 Posts: 5,713, Reputation: 339
    Plumbing Expert
     
    #3

    Mar 2, 2011, 05:03 PM

    If the furnace isn't sooted up too bad, it may be okay. I have seen units not converted soot up so bad that it clogs the heat exhanger, draft inducer etc, and at that point your best bet is to replace the complete unit. If the unit has been looked at by a pro, and it is operating correctly, you are probably okay (got lucky) with only 600 gallons through it. Just keep your eyes open for things like plugged drain system, or tripped flame rollout switches. If either of these things happens within the next few months, I would definatley raise my concerns with the installer. Other than that, your probably fine.

Not your question? Ask your question View similar questions

 

Question Tools Search this Question
Search this Question:

Advanced Search

Add your answer here.


Check out some similar questions!

Amana gas furnace starts then stops [ 5 Answers ]

The gas fires for a few seconds and then shuts off and restarts the cycle again. Usually it works the second time. Sometimes it locks out and has to be reset. I've cleaned/replaced the flame sensor. I checked the vacuum switch -ok

Amana Gas Furnace Will Not Stay Lit [ 0 Answers ]

I have a furnace that is about 20 years old. When the furnace is first turned on everything works perfectly... it lights like it supposed to and runs for around 3-5 minutes then the burner shuts off and immediately tries to relight itself. It relights and the burner only runs for around 3 seconds...

I have an Amana 90 Gas Furnace [ 1 Answers ]

I have an Amana 90 Gas Furnace with an Aprilaire thermostat. When I switch the thermostat to heat, it will not come on. The temperature reading for heat is higher than the room temperature, so that is not the problem. When I try the cool, the system works fine.

Amana gas furnace [ 1 Answers ]

Where can I find a natural to lp converter for amana furnace


View more questions Search