Ask Experts Questions for FREE Help !
Ask
    kidslice2000's Avatar
    kidslice2000 Posts: 1, Reputation: 1
    New Member
    		  
    #1

    Nov 12, 2013, 05:49 AM
    How do I build a basin out of concrete
    I built a basin out of concrete and it sunk in the middle do I cut out that section and then repour the concrete or do I start the whole thing from scratch?
    Stratmando's Avatar
    Stratmando Posts: 11,188, Reputation: 508
    Uber Member
    		  
    #2

    Nov 12, 2013, 06:29 AM
    Does the depression hurt or have any bad effects on the basin? If not leave it.
    Maybe use bond-it and pour a cap on it?
    smearcase's Avatar
    smearcase Posts: 2,392, Reputation: 316
    Ultra Member
    		  
    #3

    Nov 12, 2013, 12:41 PM
    Assume you are talking about a sink basin and not something to be used outdoors subject to freezing and thawing. If it is for outside use in cold climate, rebuild it.
    Sounds like your mix contained too much water, which creates a high slump and weakens the concrete.
    I agree with Strat's suggestions but I would also use a concrete sealant on the finished product in addition to the epoxy or other bonding material.
    If you decide to start over, use only enough water to form a paste and coat all the aggregates. And, allow time for the bottom portion to take just about an initial set before pouring the top portion which can contain a little more water and easier to get a good finish. It's referred to as "rate of pour" in construction of deep structures. Good luck.
Not your question? Ask your question View similar questions
 

Question Tools Search this Question
Search this Question:

Advanced Search

Add your answer here.


Check out some similar questions!

Can you tile over an existing concrete shower basin? [ 0 Answers ]

I have a bathroom with an existing concrete shower basin. I want to chisel out the old drain and put in a new 3 piece drain. Is there any reason that I couldn't put down a membrane on top of the existing concrete basin and tile over that?

What do I do about build up in a septic tank basin? [ 1 Answers ]

Any ideas on eliminating build up in a grinder pump basin besides enzymes andhow effective are enzymes and how often do you need to introduce them

Want to install septic pump basin in Concrete basement [ 11 Answers ]

Hi, First off let me just thank the people who contribute here because I have spent several hours reading and searching for answers... especially speedball1~been reading a lot of your posts. Okay so I am redoing my basement and I would like to put in a bathroom with a shower sink and toilet. ...

Tiling Over Concrete Shower Basin [ 6 Answers ]

I am replacing the tile on a basement concrete shower basin that has been leaking into the main area of the bathroom. The basin appears to have been poured after the floor and there are gaps between the floor and the basin. In trying to seal the basin I've asked the pros at Home Depot and they...

How to build a basin [ 1 Answers ]

I Have An Area That Is New Construction For A Bathroom. I Was Wondering If Anyone Can Turn Me On To Some Web Pages That Can Show Me How To Build A Shower Basin Out Of Morter,put The Rubber On To Water Proof It And Then Tile. Thanks

View more questions Search