Ask Experts Questions for FREE Help !
Ask
    fin3's Avatar
    fin3 Posts: 2, Reputation: 1
    New Member
    		  
    #1

    Oct 17, 2012, 11:27 AM
    Exhaust Venting
    I have a Carrier weathermaker gas furnace which is about 12 years old and works well. The exhaust piping goes up (4" pipe) then connects to a 6" pipe and then connects with elbow to an horizontal pipe (about 5' long) than connects upward to chimney. The horizontal pipe is angled slighlty downwards (about 11/2inches over the 5' lenght). Is there a safety issue with the horizontal piping sloping slightly downwards ?
    ma0641's Avatar
    ma0641 Posts: 15,675, Reputation: 1012
    Uber Member
    		  
    #2

    Oct 17, 2012, 03:25 PM
    What would happen if you cut the 4" pipe and drop it? Would the slope improve? ASHRAE code calls for 1/4" per foot positive slope. CO is not something you want in the house. You can buy piping at HD or Lowe's to make changes and I would also use approved metal tape to seal the piping.
    mygirlsdad77's Avatar
    mygirlsdad77 Posts: 5,713, Reputation: 339
    Plumbing Expert
    		  
    #3

    Oct 17, 2012, 05:53 PM
    Sloping downward toward the furnace, or the chimney? If it is sloping down to the furnace, you are fine. If it is sloping down to the chimney, that's not ideal.
    fin3's Avatar
    fin3 Posts: 2, Reputation: 1
    New Member
    		  
    #4

    Oct 18, 2012, 07:19 AM
    Quote Originally Posted by ma0641 View Post
    What would happen if you cut the 4" pipe and drop it? Would the slope improve? ASHRAE code calls for 1/4" per foot positive slope. CO is not something you want in the house. You can buy piping at HD or Lowe's to make changes and I would also use approved metal tape to seal the piping.
    I can drop the 4" pipe to improve the sloping but that will cut the headroom substantially i.e.. The horizontal pipe would be about 5 1/2' above floor (lowest point) as opposed to about 7' now. The reason it would have to drop so much is that the exhaust pipe must run above or below a water pipe. Currently it runs above the water pipe, hence the downward slope to the chimney. FYI, this was brought to my attention only recently - I haven't had any problems for 10 years. Should I go with the lower headroom for peace of mind or is it unlikely to be a problem given that there hasn't been a problem for a long time (my CO detector has never gone off) ?
    mygirlsdad77's Avatar
    mygirlsdad77 Posts: 5,713, Reputation: 339
    Plumbing Expert
    		  
    #5

    Oct 18, 2012, 04:15 PM
    If nothing else ties into the six inch pipe, it could be reduced to 4" since it is only a five foot run. Only going to gain an inch here, unless you can raise it at the chimney, which would give you a true two inches of adjustment.
Not your question? Ask your question View similar questions
 

Question Tools Search this Question
Search this Question:

Advanced Search

Add your answer here.


Check out some similar questions!

Venting basement exhaust fan [ 3 Answers ]

My basement shower exhaust fan was vented into the area above the suspended ceiling. I want to vent it outdoors, the way it should have been done the first time. The shortest way out is through the rim joist about 2 feet away. I can't go through the one floor joist in my way to get there. Is...

Venting a bathroom exhaust fan [ 13 Answers ]

I need to vent an bathroom exhaust fan in the attic. Can I run the duct up close to the roof ridge that is vented. I have no way of venting it to the outside wall since the bathroom is in the middle of the house

Bathroom exhaust fan venting [ 2 Answers ]

I am installing a bathroom in the basement and need to install an exhaust vent. There is a very spacious crawl space under the basement and the easiest way to run the vent is to exhaust into the crawl space. The crawl space is vented and as I said, it is very large (I live on a steep slope). Can...

Exhaust fan venting [ 2 Answers ]

Is it OK to vent my bathroom exhaust fan into my dryer vent? The laundry room and bathroom are side by side and the dryer vent goes directly out the side of the house (both rooms are in the basement)

Exhaust Venting a new bathroom [ 1 Answers ]

I am adding a new bathroom where an old bedroom used to be on the first floor of a two-story house w/ attic. The bathroom does not share an exterior wall; it is separated from the exterior by a room. I am having difficulty finding a pathway to install the ducting from the fan through to the attic...

View more questions Search