 |
|
|
 |
New Member
|
|
Apr 16, 2012, 03:22 PM
|
|
Why does my van die while driving
My 1993 Chevy astro van 2WD 4.3L TBI 6 cylinder dies sometimes while I am driving usually under 30 miles an hour, when I am not accelerating and sometimes while I am accelerating. I replaced the fuel pump and the screen on the bottom of it, the gasket under the injectors. The fuel filter, and the battery. The spark plugs are firing right.
Why does it still die
|
|
 |
Uber Member
|
|
Apr 16, 2012, 04:07 PM
|
|
Failing Ignition Control Module (ICM)?
|
|
 |
Cars & Trucks Expert
|
|
Apr 17, 2012, 05:31 AM
|
|
When you start the van, does the check engine light come on, flash several times and then go off and stay off?
Have you had the Idle Air Control Valve (IACV) tested and/or cleaned?
|
|
 |
New Member
|
|
Apr 18, 2012, 08:13 PM
|
|
I tested the ignition coil, the distributor and the ignition control module and they are all fine. When I start it the check engine light used to come on and off every couple of days and would go off. Its an OBD1 and when I tested it only the code 12 came up which is the OK code. Now since I made sure the battery terminal wires are all tight and reset the computer by disconnecting negative cable. Non of my lights on my dash come on immediately. The check engine light doesn't appear anymore, the anti lock brakes light comes on sometimes at start up and sometimes not for 10 or 15 minutes after I start it up. The spark plugs are firing correctly.
It seems that the van tries to die more often when it is just started up and when it is warm. When it tries to die, the oil gauge falls rapidly and I have to hit the gas pedal to keep it running.
Can I test the IACV at home or do I need to take it to a shop or autozone?
|
|
 |
Uber Member
|
|
Apr 19, 2012, 05:52 AM
|
|
Testing ICMs with a Well's machine is virtually a waste of time. Instead, I recommend replacing them every 120,000 miles or 10 years, whichever comes first. I've seen many ICMs test fine that failed to work. Ditto for coils.
|
|
 |
Cars & Trucks Expert
|
|
Apr 19, 2012, 07:17 AM
|
|
There is a specially designed harness needed to test the movement of your IACV. Most shops that do driveability work should have them. I would recommend doing a cleaning yourself first to see if anything changes as it probably will.
Get your hands on a good throttle plate cleaner and after the engine is warmed up and shut off, spray some into the throttle body and IACV and let it soak for a few minutes to work in.
Restart the engine (it will run rough at first and probably won't idle on it's own).
Keep it running about 1200-1500 RPM until all the cleaner burns out then repeat your road test. Hopefully, at least some of the symptoms will go away. Repeat if necessary until you're satisfied that any more cleaning won't improve matters. If it's till stalling/near stalling, have the IACV replace and consider also having the injectors professionally cleaned.
|
|
 |
New Member
|
|
Apr 22, 2012, 06:44 PM
|
|
OK I found a relay to the fuel pump that was bad and replaced it, today now the engine is trying to kick on, but there is not any fuel coming up to the injectors.
I just replaced the fuel pump, filter, screen, had the wiring tested and everything was good yesterday, now today the fuel pump isn't even trying to pump. I listened for the whirling noise and nothing is happening. I cleaned the throttle body and it wasn't dirty. I replaced the pickup coil on the bottom of the distributor and we got it back in perfectly no problem there. I don't have a camshaft sensor or a crankshaft sensor. The fuel lines aren't plugged, but the fuel pump isn't doing its job.
|
|
 |
Uber Member
|
|
Apr 22, 2012, 07:10 PM
|
|
Check all under dash and under hood fuses with a test light or multimeter.
|
|
 |
New Member
|
|
Apr 23, 2012, 02:28 AM
|
|
I forgot to say this, but I also checked all the fuses.
|
|
Question Tools |
Search this Question |
|
|
Add your answer here.
Check out some similar questions!
I was involved in a car wreck in June, I was driving my friends van..
[ 2 Answers ]
I was driving my friends van and rear ended someone. Her van was totaled. It is now October and for the past month I have had chronic lower back pain. I had an MRI and I have a bulging disc and no insurance. By the way I didn't want to drive her van but she couldn't go to a basketball...
Why does Honda Accord die while driving?
[ 1 Answers ]
I read the answers on the site. Anyway to narrow the problem down?
I have a 1999 Honda Accord. It has never had a problem starting. Over the last month the RPM gauge has dropped down to zero while driving it - either on I95 going 60 mph or on back roads. If I step hard on the gas it picks...
Mini van 1999 dies while driving
[ 1 Answers ]
So I'm just driving along and my car will die. I can put it in park and it will start right back up no problem. I've checked the connections on the battery and alternator. What could be causing this?
View more questions
Search
|