View Full Version : How to wire a rx95 starter
jbass1977
May 12, 2010, 03:10 PM
Did a engine swap from a brigs to a kawa both 12.5hp unable to get the fuse to stop blowing out when turning the key on and turning over the motor
cdad
May 12, 2010, 03:20 PM
On the starter relay is there 1 small wire or 2? You may have a ground wire hooked to the wrong connection. I pole should active the solenoid and the other should go hot only when the soleniod is active. Check that first.
jbass1977
May 12, 2010, 03:30 PM
OK on the starter there is two posts I have run the large red wire from the soleniod to the first post and the small red wire that comes from the key switch (fused wire) to the front post and the third is a quick connect plug and I have grounded that out. The engine turns over with the starter wired this way but within 1 / 2 sec. the fuse blows
jbass1977
May 12, 2010, 03:54 PM
I could really use a wire diagram for the starter that might get me the jist of it
cdad
May 12, 2010, 03:58 PM
Is the quick connect wire hooked to the starter soleniod?
Should be 2 large posts and one or two small ones on the soleniod. How many are there on the soleniod? ( of the small posts)
jbass1977
May 12, 2010, 04:00 PM
One on the soleniod and this is what I have run the ground to the two large posts have the hot wires to them