PDA

View Full Version : Furnace will only run for 30 minutes then shuts down.


Old Dragon
Feb 17, 2008, 01:13 PM
I have a Bryant Plus 90 furnace that has operated well for years. Last Monday the outside temp dropped to 3 degrees... I woke due to shivering and realized that the furnace was not operating. I checked all the fuses and everything else I could think of and when I replace the skins the furnace turned on and seemed to run as usual. This only lasted a short time,and after trial and error I can get it too run for about 45 minutes at a time only after turning off the thermostat for about 30 minutes then turning the thermostat back on. The furnace starts normally but shuts off after 45 minutes or if it reaches the set temp. Even if it turns off at the set temp it will not restart. I called a number of furnace companies and they charge an average of 75 dollars just to show up then $300 to look at a furnace, this cost is not including any parts or labor. Since this cost is way beyond what someone of a disability pension can afford I have been heating my home 45 minutes at a time. I have checked the blower too see if the bearings are bad and it moves as freely as it always has. There are no noises or any other symptoms of failing parts... except that is that it shuts down for no good reason... can anyone help?

T-Top
Feb 17, 2008, 06:50 PM
check the lower door on the furnace you should see a blinking light it will give you the code to what's wrong. My guess is 3 flash pause 1 flash= code 31 pressure switch did not close or reopen-- fault-- froze condensation drain or restricted vent.

Stubby74
Feb 18, 2008, 04:44 AM
Agree with above... check your drain... if it is slow or frozen it will close a switch. Which will shut you down.

airfx
Jan 28, 2011, 10:25 AM
It is definitely a venting or drainage problem. The condensate is not getting out of your furnace. This is due to either a plugged drain as the above mentioned or water sitting in a part of the vent due to sagging vent or an elbow to low and not slopping back to the furnace allowing water to sit in that elbow.