Ask Experts Questions for FREE Help !
Ask
    Zoedog's Avatar
    Zoedog Posts: 2, Reputation: 1
    New Member
    		  
    #1

    Jan 28, 2011, 12:53 PM
    Grundfos recirc pump - ticking noise and pump warm to the touch - Normal?
    We have an approx 8 y/old Grundfos recirc pump on our hot water line and today I notice it is making a ticking noise (first time I've noticed this) and it is "quite" warm to the touch--I've never touched it before so I'm not sure if this is always the case. Should I be worried? I don't recall that it made a ticking sound previously and I'm about to go out of town overnight... any help is apreciated.
    massplumber2008's Avatar
    massplumber2008 Posts: 12,832, Reputation: 1212
    Senior Plumbing Expert
    		  
    #2

    Jan 28, 2011, 01:02 PM

    Hi Zoedog...

    As long as the delivery of hot water is as it has always been then you are fine. Pumps run and get warm/hot, but the pump should shut down when the thermostat is satisfied. The ticking sound isn't exactly "normal", but not unreasonable either.

    If hot water delivery takes longer at the farthest faucet, for example, then you may have a bad pump but it certainly poses no danger as worst case it just won't circulate water anymore... ;) In this case, just get it replaced when you get home this weekend.

    Good luck!

    Mark
    Zoedog's Avatar
    Zoedog Posts: 2, Reputation: 1
    New Member
    		  
    #3

    Jan 28, 2011, 01:17 PM
    Thank you for your quick answer Mark! Now I can have piece of mind. Cheers!
Not your question? Ask your question View similar questions
 

Add your answer here.


Check out some similar questions!

Grundfos circulation pump problem? [ 0 Answers ]

Hi, We have a radiant heating system in the kitchen area. The Grundfos circulation pump was installed by previous owner. It was working fine until about a week ago when we had a power outage for about 7 hours in cold weather, it is not making a low sound that seems like it is running non-stop....

Where can I find Grundfos 15-18 FS pump repair parts? [ 1 Answers ]

I use a Grundfos 15-18 FS pump for hot water circulation. While the water to the house was turned off the pump kept running and I believe ruined the pump parts inside. I want to find/buy repair parts new or used. Any idea where to find them?

Grundfos pump on demand electricity usage [ 1 Answers ]

I swithched from a grundfos pump on demand to a jet pump / pressure tank system thinking I would save electricity since the grundfos starts up every time water is called for. Does anyone know if I did the right thing or if I wasted my time and money?

Physical mounting of hot water recirc pump [ 6 Answers ]

I purchased a grundfos recirculation pump for my hot water system and I'm planning the installation. The thing is pretty heavy and there are no attach points to mount the pump itself. I'm installing it on a wall with 16" center studs. With only 1/2" copper spanning the 16" with the pump...

Recirc pump runs very hot [ 4 Answers ]

Hi, I'm replacing a recirc pump while also installing a new water heater. It's a Taco 1/2" model and I'm concerned about how quickly it heats up and how hot it gets; concerned enough that I've not actually run it for more than 10 minutes for fear of damaging it. It gets almost too hot to...

View more questions Search